Spatial modeling of the nonstationary processes of boiling liquid outflows from high pressure vessels
DOI:
https://doi.org/10.7242/1999-6691/2014.7.4.33Keywords:
boiling liquid outflow, mathematical and numerical modeling, vaporizationAbstract
The nonstationary processes of boiling liquid outflows following high-pressure vessel depressurization are studied. The two-phase model of a boiling vapour-liquid mixture is extended to solve spatial problems in the case of axial symmetry, where single velocity, single temperature and single pressure approximations are valid, using a wide range equation of state for water and steam in analytical form (R.I. Nigmatulin, R.Kh. Bolotnova). Numerical simulation of two-phase processes is implemented on moving (Lagrangian) meshes using the shock-capturing method. The peculiarities of formation of boiling liquid jets during the explosive outflow of water from high pressure vessels are studied for different initial state parameters of saturation close to the thermodynamic critical point. The calculated spatial distributions of volume vapour concentration and pressure and velocity fields are presented. It has been found that the jet has a conical form when the initial saturation temperature of water is below 480 K. A further increase in the initial saturation temperature up to the critical point leads to twisting of the jet against the flow direction and to its “sticking” to the sidewall, so that the cone opening angle increases to 180°. The values of supersonic and subsonic regimes of outflow are determined using the Mach numbers. Qualitative agreement between calculated and experimental data (A.V. Reshetnikov, N.A. Mazheiko, etc.) is obtained.
Downloads
References
Sokolov E.I. Upravlenie teceniem zidkosti i gaza na mikromasstabe. - SPb.: Izd-vo SPbGPU, 2012. - 39 s.
2. Sipatov A.M., Karabasov S.A., Gomzikov L.U., Abramcuk T.V., Semakov G.N. Primenenie metodov trehmernogo modelirovania pri konstruirovanii pnevmaticeskih forsunok // Vycisl. meh. splos. sred. - 2013. - T. 6, No 3. - S. 346-353. DOI
3. Ivandaev A.I., Gubajdullin A.A. Issledovanie nestacionarnogo istecenia vskipausej zidkosti v termodinamiceski ravnovesnom priblizenii // TVT. - 1978. - T. 16, No 3. - S. 556-562.
4. Edwards A.R., O’Brien T.P. Studies of phenomena connected with the depressurization of water reactors // J. Br. Nucl. Energ. Soc. - 1970. - Vol. 9, no. 2. - P. 125-135.
5. Nigmatulin R.I. Dinamika mnogofaznyh sred. - M.: Nauka, 1987. - C. 1. - 464 s.
6. Sagapov V.S., Alaev A.V. Ob"emnoe vskipanie zidkosti, soderzasej gazovye zarodysi // TOHT. - 2012. - T. 46, No 4. - S. 420-431. DOI
7. Pinhasi G.A., Ullmann A., Dayan A. 1D plane numerical model for boiling liquid expanding vapor explosion (BLEVE) // Int. J. Heat Mass Tran. - 2007. - Vol. 50, no. 23-24. - P. 4780-4795. DOI
8. Ivasnev O. E. Ob osobennostah modelirovania tecenij kipasej zidkosti // MZG. - 2008. -No 3. - S. 64-76.
9. Bolotnova R.H., Buzina V.A., Galimzanov M.N., Sagapov V.S. Gidrodinamiceskie osobennosti processov istecenia vskipausej zidkosti // Teplofizika i aeromehanika. - 2012. - T. 19, No 6. - C. 719-730.
10. Pribaturin N.A., Bezrukov U.A., Bykov M.A., Krasnov S.N., Onsin V.M., Leznin S.I., Sorokin A.L. Issledovanie strui pri istecenii vskipausej vody pri razryve truboprovoda // Materialy 4-j Rossijskoj nacional’noj konferencii po teploobmenu. - 2006. - T. 5, No 6. - S. 284-287.
11. Resetnikov A.V., Mazejko N.A., Beglecov V.N., Skokov V.N., Koverda V.P. Dinamika pul’sacij pri vzryvnom vskipanii struj peregretoj zidkosti // Pis’ma v ZTF. - 2007. - T. 33, No 17. - C. 31-37. DOI
12. Nigmatulin R.I., Bolotnova R.H. Sirokodiapazonnoe uravnenie sostoania vody i para. Uprosennaa forma // TVT. - 2011. - T. 49, No 2. - S. 310-313. DOI
13. Sevelev U.D. Prostranstvennye zadaci vycislitel’noj aerogidrodinamiki. - M: Nauka, 1986. - 367 s.
14. Labuncov D.A., Kol’cugin B.A., Golovin V.S., Zaharova E.A., Vladimirova L.N. Issledovanie pri pomosi skorostnoj kinos"emki rosta puzyr’kov pri kipenii nasysennoj vody v sirokom diapazone izmenenia davlenij // TVT. - 1964. - T. 2, No 3. - S. 446-452.
15. Scriven L.E. On the dynamics of phase growth // Chem. Eng. Sci. - 1959. - Vol. 10. - P. 1-13. DOI
16. Older B., Fernbah S., Rotenberg M. Vycislitel’nye metody v gidrodinamike. - M.: Mir, 1967. - 384 s.
17. Agiseva U. O., Bolotnova R.H., Buzina V.A., Galimzanov M.N. Parametriceskij analiz rezimov udarno-volnovogo vozdejstvia na gazozidkostnye sredy // MZG. - 2013. - No 2. - C. 15-28. DOI
18. Kuropatenko V.F., Mustafin V.K. Metodika rasceta nestacionarnyh tecenij v mnogokomponentnyh neravnovesnyh smesah vesestv // Vestnik CelGU. - 1997. - T. 6, No 1. - S. 97-102.
19. Buzina V.A. Nestacionarnoe prostranstvennoe istecenie gazonasysennoj zidkosti iz osesimmetricnyh sosudov // Vestnik Baskirsk. un-ta. - 2013. - T. 18, No 3. - S. 636-639.
20. Sedov L.I. Metody podobia i razmernosti v mehanike. - M.: Nauka, 1977. - 440 s.
21. Wagner W., Pruss A. The IAPWS formulation 1995 for the thermodynamic properties of ordinary water substance for general and scientific use // J. Phys. Chem. Ref. - 2002. - Vol. 31, no. 2. - P. 387. DOI
Downloads
Published
Issue
Section
License
Copyright (c) 2014 Computational Continuum Mechanics
This work is licensed under a Creative Commons Attribution-NonCommercial 4.0 International License.